In the great quest to get Americans eating healthier, spinach is an unusual success story. Were consuming four times as much fresh spinach as we were four decades ago, as a vegetable once derided as choke-it-down good for you has become a mainstay of home cooking and upscale restaurants. But the spinach boom wasnt driven by changing tastes, or the cartoon exhortations of Popeye. It was driven by technology.

Spinach, like many vegetables, is finicky. If you packaged it in the same airtight bags used for potato chips, the leaves would start to break down before they made it from Californias Central Valley to a supermarket in Chicago. It wasnt until scientists came up with a special bagone that controls how much oxygen and carbon dioxide can seep in and outthat pre-washed, ready-to-eat spinach became something that a shopper could grab in the produce section and dump straight into a salad bowl or smoothie. Spinach, and leafy greens in general, have become so convenient that Americans are actually eating more of theman impressive feat considering just one in 10 Americans eats the recommended servings of fruits and vegetables each day.

As the country seeks solutions to the obesity epidemic, theres been plenty of debate about how to get people to eat better. Do we need to improve access to healthy foods? Teach cooking? Tax sugary drinks? But theres one thing thats often left out of the conversation: technology.

It might seem strange to think about vegetables as a technology, but they are. The average supermarket produce aisle represents decades, if not centuries, of agricultural research and development. But in the United States, big-league commodity crops like corn and soy, as well as meat, gobble up most of the agricultural research investment from both the public and private sectors. The U.S. Department of Agricultures dietary guidelines tell us to fill half our plate with fruits and vegetables to maintain a healthy diet, but its research priorities are far different. So-called specialty cropsthe governments name for the category that includes, essentially, all fruits, vegetables and nutsreceived just 15 percent of the federal research budget over much of the past three decades.

Theres nothing more important we can do to improve the health of this country than to invest billions and billions into researching the fruits and vegetables that were encouraging people to eat, said Sam Kass, the former White House chef and food policy guru under the Obama administration who now works with food tech startups.

Agricultural research is fundamental to improving how we raise, grow, harvest, process and ship everything that we eat. It took millions of dollars of public and private research and years of experimenting with limp leafy greens before breathable salad packaging came onto the scene. Consumers no longer have to wash sand and dirt off their greens, remove tough stems and ribs or chop them into bite-sized portions. The same types of technologies have also helped bring us baby carrot packs with dips, sliced apples in McDonalds Happy Meals and ready-to-eat kale salad kits.

Packages of Fresh Express salad wait for customers in a San Francisco grocery store. The technology that keeps spinach and lettuce fresh in breathable packaging was based on government agricultural research conducted in the 1950s. | Getty

The enormous logistical and technological challenges facing so many of the foods that nutritionists tell us to eat make research especially critical for produce, which as a sector is still relatively inefficient. Apples bruise. Berries don't all ripen at once. Cilantro wilts. Cherries can split and crack if it rains at the wrong timea problem that can be so expensive, some growers hire helicopters to fly over their crop to dry the delicate fruit. Many of these crops still rely on increasingly expensive (and oftentimes undocumented) labor to pick them by hand. And water. They need lots of water.

Specialty crops remain specialjust 3 percent of cropland is dedicated to growing themthough they make up roughly a quarter of the value of crops grown in the U.S. because they demand higher prices. This lopsided dynamic means that specialty crops have historically received very little federal research investment compared to their value. It also means the country simply doesnt have a food system that supplies what were told to eat. In 2007, there were about 8.5 million acres of specialty crops in a sea of more than 300 million acres of everything else.

If Americans were to actually go ahead and jump into consuming the amount of fruits and vegetables recommended, wed be hard-pressed to meet that demand, said Sonny Ramaswamy, director of the USDAs National Institute for Food and Agriculture, which coordinates a large part of the governments agricultural research portfolio. Theres an incredible amount of innovation that we need, all the way from the farm to the table.

The imbalance is no accident: In a sense, its built into the mission of the USDA itself, which frustrates both vegetable growers and nutrition advocates. But there are signs its starting to changeif slowly.

THE ROAD TO packaged salad isnt just an example of how research pays off: It shows just how long the process can be, and how much commitment it requires. It began in the late 1920s when a young Berkeley grad named Bruce Church bought a field of head lettuce in Salinas, California, and devised a plan to ship it, packed in ice, by rail across the United States. According to local lore in the Salinas Valley, children as far away as Maine would greet the rail cars excitedly, shouting: "The icebergs are coming! The icebergs are coming!" The name stuck.

After World War II, a handful of USDA scientists stationed in Fresno, California, set out to learn more about how to best handle, store and ship fruits and vegetables. They obsessively measured temperatures, shelf life, spoilage and the rate at which different crops respireor breathewhich is one way of measuring how fast something will rot.

Theyre still alive! explained Gene Lester, national program leader for the Agricultural Research Services food science and technology division. Youre eating a lettuce leaf or a kale leaf, or a string bean, or an appletheyre still alive. Theres still CO2 and oxygen exchanging in those organisms, and thats whats keeps them healthy for us.

A vintage poster for Bruce Church, Inc., the Salinas, California company that helped popularize iceberg lettuce starting in the 1920s. Bruce Church Inc. later morphed into Fresh Express, which pioneered the use of breathable packaging for lettuce and other leafy greens. | Fresh Express

In 1954, researchers published a roundup of everything theyd learned in a massive book, known as AH-66. That tome served as a base of knowledge that preceded major advances in produce innovation for decades afterward. That was kind of a bible for us, said Jim Lugg, a longtime agriculture scientist who in many ways is the grandfather of modern salad technology. The problems werent really with growing the crops, it was with shipping them and keeping them fresh. Lugg, whos now 83 years old, still consults in the industry (and, for the record, still eats lots of salad).

In 1963, Lugg signed on to lead the research division of Bruce Church Inc., which teamed up with a subsidiary of refrigerator-maker Whirlpoola partnership based largely on the hope that they might be able to figure out how to get lettuce from Salinas to the East Coast before it turned brown. After a lot of experimentation, they figured out how to manipulate the atmosphere inside the vehicles in which they shipped the lettuce so that it was more hospitable, providing the right balance of CO2 and oxygen in refrigerated rail cars and containersa hack that took the shelf life of the lettuce from three or four days to 14, as long as the lettuce was kept cold.

Weve put it to sleep, Lugg explained. Its sleeping! Its not breathing at its normal rate.

Bruce Church Inc. eventually morphed into Fresh Express, which in 1989 introduced what is believed to be the first pre-washed, bagged salad in grocery stores nationwide. That first mix, packaged in breathable bags, was chopped iceberg lettuce, with bits of shredded carrots and purple cabbage, a combo that meant home cooks could serve a multi-ingredient salad without chopping a single vegetable. We saw a way to really improve the customer experience with lettuce, Lugg said.

Lugg recalled serving on a board that helped advise the government on investing in specialty crop research in the 1990s. I dont think they were spending very much, he says. (USDA couldnt provide an estimate.) The then-head of [the Agricultural Research Service] was very defensive about all the problems they had getting money and that they had to spend money for things like corn and ethanol and cotton.

Hed sometimes give Ed Knipling, the then-head of ARS, a hard time about the disparity. He would point out how much they spent on this crop or this crop, and wed say Well, how much did you spend on lettuce?

SO WHY DOESNT the nation spend more on better lettuce? The answer lies partly in the history of the U.S. Department of Agriculture itself. On one hand, the department, founded by Abraham Lincoln, is dedicated to promoting and boosting American agriculture as an industry. That means investing in the massive commodity crops that largely fuel American farming, giving us the cheapest, most abundant food supply in the history of the world. But the department is also tasked with encouraging healthy eatingits the agency that gives Americans nutrition adviceand these two major goals can at times be directly at odds.

Public health advocates have long lamented that the USDAs nutrition advice doesnt align with how the institution actually spends its money, and they often point to crop subsidies as the most glaring example. Between 2008 and 2012, for example, fruits and vegetables and other specialty crops got just under one-half of 1 percent of all the subsidies that were doled out. A full 80 percent of those payments went to supporting grains used in all manner of foods, to feed livestock and to fuel our cars, and oils, like what we use to fry potato chips.

The disparity is something that frustrates Rep. Chellie Pingree, a Democrat from Maine, who also happens to be an organic farmer. When the congresswoman speaks at food conferences, she often shows a side-by-side graphic comparing MyPlate, the governments nutrition guide, and a plate representation of crop subsidies.

Vegetables are called specialty crops! Dont ask me to explain why, Pingree said as she unveiled her graphic at TedxManhattan back in 2014. The room full of foodies gasped and mumbled disapprovingly.

The idea that junk food is cheaper than produce because of farm subsidies is so often repeated by food movement leaders like Michael Pollan that almost everyone assumes that its true. But the reality is more nuanced.

Subsidies on their own dont explain why processed foods are cheaper than produce, calorie for calorie. Fruits and vegetables, first and foremost, are highly perishable, which makes everything about growing, harvesting, storing and shipping them infinitely more complicated and expensive. Many of these crops also take a ton of labor to maintain and harvest. Economists whove crunched the numbers have found that removing agricultural subsidies would have little effect on consumers food prices, in part because the cost of commodities like corn and soybeans represent just a tiny share of the cost of the food sold in the grocery store.

The U.S. has simply gotten much better at growing corn than lettuce. Today, we get about six times as much corn out of one acre of land as we did in the 1920s, when Bruce Church started his lettuce farm. Iceberg lettuce yields, on the other hand, have only doubled in that time. The USDA didnt start tracking such data for most of the darker leafy greens until the 1990s.

Even if subsidies did make fruits and vegetables dramatically cheaper, its far from clear that everyone would start eating their broccoli. The price of produce isnt the only cost to eating fruits and vegetables; many consumers also lack the time or the skills to prepare and cook their perishables. And increasing fruit and vegetable consumption is hard to keep up as Americans eat more of their food on the go, away from home and prepare far fewer traditional meals on their own.

Moreover, the produce industry doesnt want to be subsidized like Big Corn or Big Soy. When industry leaders come to Capitol Hill, they have been clear that they didnt want traditional subsidies, like price supports, said Glenda Humiston, vice president of agriculture and natural resources at the University of California. They want help with the infrastructure to do their jobs better, she says, including more funding for research labs and data collection that can help industry solve problems on the ground.

Migrant workers pick organic spinach in a field in Colorado. Labor, often from immigrant workers, remains one of the most costly inputs to growing healthy fruits and vegetables. | Getty

Reducing the need for labor is one of the top priorities for the industry, especially with the Trump administrations rhetoric and recent crackdown on undocumented workers. Labor alone can account for half a farms costs and labor shortages are already preventing the expansion of acreage of specialty crops in many regions. Farmers can be hesitant to invest in growing, watering and raising a crop if theres uncertainty about having enough workers to harvest it.

Growers and shippers are going to have to find ways to mechanize, or were not going to be able to harvest our products, and were talking about delicate products, said Steve Church, CEO of Church Brothers Farms, a major grower in Salinas.

The biggest issue we have here is labor, Church added. No question in my mind.

Today, the government is funding research at Washington State University and other universities to design robots that can gently harvest apples and even see or smell when the fruit is ripea potential leap for the kind of mechanization that has so far eluded much of the produce industry.

USDA researchers are also working on a system that drastically cuts down on the need to sort fruit. The prototype is an elaborate, six-armed machine that goes into the field with apple pickers. The apples are fed onto a conveyer belt that uses an infrared system to detect blemishes and even grade the fruit on the spot.

Other research is focusing on improving flavor. In Florida, researchers have cracked the code to make tomatoes taste better, an innovation that could help reverse decades of breeding tomatoes for durability and thick skin that has left the fruit tasteless and watery. The tomatoes, which also have more lycopene, an important nutrient and anti oxidant, have begun being marketed in Florida under the name Tasti-Lee. The company that commercialized the technology says nearly 94 million pounds of the tastier tomato have been sold so far.

We first of all had to have a stable supply. We had to figure out how to get tomatoes from the West Coast to the East Coast, says a USDA scientist, permitted to speak on background. But now we can focus on the whole flavor component.

Making tomatoes tastier is only the beginning. Understanding this pathway, its not unique to just tomatoes, but you can use this as a model for citrus, or peppers or apples or anything else, the scientist said.

THOUGH SPECIALTY CROPS have lagged behind their shelf-stable brethren for much of the past century, the needs of the produce industry havent gone totally unheard in the halls of Washington. The idea that these smaller crops might deserve more attention began to gain some traction in the early 2000s, when California growers became increasingly angry that their state was the No. 1 agriculture state based on value, largely due to high-dollar specialty crops, but they were coming up around 16th in terms of USDA research funding coming into the state.

In 2006, there was also a renewed interest in investing in research after a deadly E. coli outbreak linked to packaged spinach rocked the entire produce industryand consumer confidence. Three people died, and 276 people were hospitalized. The disaster fueled an intense food-safety push across Salinas Valley and the rest of the produce industry. It also helped energize a diverse coalition of growers that had started to organize to ask Washington for a greater share of spending in the farm bill, the law that every five years sets the agenda for the Agriculture Department. They demanded that more money be invested in food safety and other types of research. Producers of commodities like dairy and grains were less than pleased to have another group vying for a part of the federal pie, according to congressional aides.

It was a hell of a fight, said Humiston.

But Big Produces political push has paid off. In 2008, the farm bill for the first time included a section dedicated to specialty crops. Theres now a $72 million fund to promote various specialty crop projects, like building hoop houses to extend the growing season. Fruit and vegetable farmers are also starting to get access to the same government-subsidized insurance policies that other commodities have enjoyed for years. But the biggest growth for specialty crops in recent years has been in research spending.

The USDA now dedicates some $400 million to studying specialty crops each yeara big increase, though still a modest fraction of the nearly $3 billion the government invests in agricultural research each year. That pot of money is spread among USDAs in-house research, land grant universities and other public research institutions. The USDA couldnt provide specialty crop research estimates from before 2008.

The Obama administration and its intense focus on healthy eating was also a boon to the specialty crop sector. The administration not only backed allocating more money to the crops, but it also promoted more fruits and vegetables in school meal programs that serve 30 million children each day, and in the Women, Infants and Children program, which provides nutritional support for half of all babies born in the United States.

While much of the new federal boost for produce investment is motivated more by the industrys business needs than any push to combat the nations crippling obesity epidemic, public health advocates with little political clout are thrilled to see the needle moving, however it happens.

If what we want is for people to eat fruits and vegetables, we have to make it easier, we have to make it taste better, said Marion Nestle, a food studies professor at New York University and author of the popular blog Food Politics.

Its about time produce got some attention.

Link:

The vegetable technology gap - Politico