Updated at 10 p.m. EDT June 30 (0200 GMT July 1).

An experimental solar wing sent to the International Space Station earlier this month was jettisoned from the orbiting labs robotic arm after engineers were unable to fully retract the array.

The disposal followed an otherwise successful test of the power panels novel roll-out deployment technique, which engineers say could help future spacecraft generate more electricity and still fit inside the fairings of existing rockets.

Carried to the space station inside a SpaceX Dragon supply ship, the Roll-Out Solar Array ROSA is an experiment sponsored by the U.S. Air Force to measure its performance in space for the first time. Rolled up in a spool fastened inside the Dragon capsules unpressurized trunk, ROSA was extracted with the stations Canadian-built robotic arm and extended to a length of more than 15 feet (4.5 meters).

The solar array unfurled June 18, extending like a party favor with tensioning booms on both sides of the 5.5-foot-wide (1.6-meter-wide) wing.

The unique design of the experimental solar array is different from the way solar panels on existing satellites deploy. Current solar panels unfold like an accordion using mechanical hinges, but the roll-out design could save volume and mass on future missions, officials said.

The problem is these traditional methods are bulky and they tend to be heavy, and we just cant make them any bigger, said Jeremy Banik, ROSAs principal investigator at the Air Force Research Laboratory at Kirtland Air Force Base, New Mexico. Thats what it comes down to. ROSA solves this problem by reducing mass by 20 percent and reducing stowed volume by 400 percent over these traditional approaches.

Youre really limited by the surface area of the bus that youre mounting it to, Banik said of current solar array designs. And you can only stack so many panels up before you run into the volume limitation of your launch vehicle fairing.

Engineers observed the behavior of the solar array as the space station sailed through day and night during each 90-minute orbit of Earth, exposing it to extreme temperature swings. A mechanical actuator also introduced vibrations and oscillations to gauge the arrays response to structural loads, and engineers measured the power production from solar cells attached to the panel.

The experiments went well, NASA said, but ground controllers were unable to lock the solar panel back in its stowed configuration after rolling it up last Saturday. Officials opted to re-extend the array before a control center in Canada commanded its release Monday, an eventuality foreseen by the solar panels designers, who added a built-in jettison mechanism to the structure.

Officials did not intend to retrieve the solar array, but mission managers planned to roll up the panel and return it to the Dragon spacecrafts external payload bay, which will burn up in Earths atmosphere Monday when the commercial cargo carriers pressurized capsule heads for a parachute-assisted splashdown in the Pacific Ocean.

The Dragon capsules homecoming was scheduled for Sunday, but NASA and SpaceX officials on Friday delayed the departure and splashdown due to a forecast of unacceptable sea states in the landing zone.

The operations team executed the (solar array) jettison procedure that was developed as part of the pre-flight planning process that covered various scenarios, NASA said in a statement. ROSA will not present any risk to the International Space Station and will not impact any upcoming visiting vehicle traffic.

The uncontrolled solar array will likely stay in orbit several months until it succumbs to atmospheric drag, which will pull it back into the atmosphere for a destructive re-entry.

The robotic arm returned the solar arrays attachment plate to the Dragon capsules trunk for disposal.

Developed by Deployable Space Systems of Goleta, California, in partnership with the Air Force and NASA, the Roll-Out Solar Array tested solar cells capable of generating up to 300 watts of electricity. But future versions of the solar panel could extend to much greater lengths, producing as much as 500 kilowatts of power, according to Banik.

Commercial communications satellites currently operate on no more than about 25 kilowatts of electricity. Higher-power spacecraft are needed to feed large ion engine drives that could propel space probes to other planets, or help maneuver military satellites between different orbits around Earth.

The Roll-Out Solar Array technology opens up applications for things like solar-electric propulsion, Banik said. NASA is considering that for interplanetary missions. Certainly, the Air Force is interested from a LEO to GEO (low Earth orbit to geostationary orbit) transfer perspective. There are some really cool applications for ROSA coming down the pike.

Space Systems/Loral, a California-based manufacturer of large telecommunications satellites, has selected the ROSA technology for potential use on future broadcasting spacecraft.

High-strain composites at the core of the prototype solar array could also be used in other deployable space structures, such as radar antennas, communications antennas and solar sails, Banik said.

The Dragon spacecraft arrived June 5 at the International Space Station, two days after its launch from NASAs Kennedy Space Center in Florida on a Falcon 9 rocket. The recycled cargo freighter is on its second flight to the space station, following a 34-day mission in September and October 2014.

The capsule also delivered a NASA astrophysics instrument designed to study the nature of neutron stars, a commercially-developed Earth observation platform, a habitat with rodents for research into a new drug that could fight osteoporosis, among other experiments.

The unpiloted capsule carried5,970 pounds (2,708 kilograms) of equipment and experiments for unpacking by astronauts and the stations robotic arm. The station crew will finish loading cargo heading back to Earth before closing the hatches leading to Dragon on Saturday.

If weather and sea conditions in the splashdown zone are deemed favorable, the Dragon capsule will be unberthed from its attachment port on the stations Harmony module Sunday, then released from the robotic arm via a command from astronaut Jack Fischer at 2:28 a.m. EDT (0638 GMT) Monday. A series of thruster firings will send the craft a safe distance from the space station for a de-orbit braking burn.

The pressurized section of the Dragon cargo craft will head for a splashdown in the Pacific Ocean about 260 miles (420 kilometers) southwest of the California coast at 7:56 a.m. EDT (1146 GMT) Monday, while the unpressurized module will break apart and burn up in the atmosphere.

Email the author.

Follow Stephen Clark on Twitter: @StephenClark1.

Go here to read the rest:

Prototype solar array jettisoned as Dragon capsule prepares for trip ... - Spaceflight Now